VALVOLINE INC -- CARBURTR TUNEUP, 00008700 -- 6850-00N038657 
=====================  Product Identification  =====================

Product ID:CARBURTR TUNEUP, 00008700
MSDS Date:05/14/1990
FSC:6850
NIIN:00N038657
=== Responsible Party ===
Company Name:VALVOLINE INC
Box:14000
City:LEXINGTON
State:KY
ZIP:40512
Country:US
Info Phone Num:606-264-7000
Emergency Phone Num:606-274-5263
CAGE:GO029
=== Contractor Identification ===
Company Name:VALVOLINE INC
Box:14000
City:LEXINGTON
State:KY
ZIP:40512
Phone:(606) 268-7000
CAGE:GO029
Company Name:VALVOLINE OIL CO
Address:3499 BLAZER PKY
Box:14000
City:LEXINGTON
State:KY
ZIP:40512
Country:US
Phone:606-357-7206 / 800-274-5263
CAGE:72527

=============  Composition/Information on Ingredients  =============

Ingred Name:ING 9:PROPER AUTH AS REQ, THAT A SPILL HAS OCCURED.
RTECS #:9999999ZZ

Ingred Name:RESP PROT:UNDER SPECIFIED CNDTNS. ENGINEERING OR
    ADMINISTRATIVE CONTROL SHOULD BE IMPLEMENTED TO REDUCE EXPOSURE.
RTECS #:9999999ZZ

Ingred Name:EFTS OF OVEREXP:BEEN SUGGESTED AS CAUSE OF FOLLOWING EFTS
    IN HUMANS:LIVER ABNORM, EYE DAMAGE. NOTE:TOLUENE (ING 13)
RTECS #:9999999ZZ

Ingred Name:ING 12:(CAS # 108-88-3) APPEARS ON THE NAVY LISTING OF
    OCCUPATIONAL CHEMICAL REPRODUCTIVE HAZARDS. CONSULT WITH (ING 14)
RTECS #:9999999ZZ

Ingred Name:ING 13:APPROPRIATE HEALTH PROFESSIONALS CONCERNING THE
    LATEST HAZARD LIST INFORMATION & SAFE HANDLING & USE RECS .
RTECS #:9999999ZZ

Ingred Name:PROPANE
CAS:74-98-6
RTECS #:TX2275000
Fraction by Wt: 25-30%
OSHA PEL:1000 PPM
ACGIH TLV:SIMPLE ASPHYXIANT

Ingred Name:TOLUENE  (SARA III)
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 30-35%
OSHA PEL:200 PPM/150 STEL
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS

Ingred Name:METHANOL;(METHYL ALCOHOL)
CAS:67-56-1
RTECS #:PC1400000
Fraction by Wt: 20-25%
OSHA PEL:S,200PPM/250STEL
ACGIH TLV:S,200PPM/250STEL; 93
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS

Ingred Name:ACETONE  (SARA III)
CAS:67-64-1
RTECS #:AL3150000
Fraction by Wt: 10-15%
OSHA PEL:1000PPM
ACGIH TLV:750PPM/1000STEL;9293
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS

Ingred Name:DIACETONE ALCOHOL (4-HYDROXY-4-METHYL-2-PENTANONE)
CAS:123-42-2
RTECS #:SA9100000
Fraction by Wt: 1-5%
OSHA PEL:50 PPM
ACGIH TLV:50 PPM

Ingred Name:SUPP DATA:GROUNDED AND/OR BONDED WHEN MATERIAL IS
    TRANSFERRED.
RTECS #:9999999ZZ

Ingred Name:SPILL PROC:CLEAN-UP HAS BEEN COMPLETED. STOP SPILL AT
    SOURCE, DIKE AREA OF SPILL TO PVNT SPREADING, PUMP LIQ (ING 8)
RTECS #:9999999ZZ

Ingred Name:ING 7:TO SALVAGE TANK. REMAINING LIQ MAY BE TAKEN UP ON
    SAND, CLAY, EARTH, FLOOR ABSORB, OR OTHER ABSORB MATL (ING 9)
RTECS #:9999999ZZ

Ingred Name:ING 8:& SHOVELED INTO CNTNRS. PVNT RUN-OFF TO
    SEWERS,STREAMS OR OTHER BODIES OF WATER. IF RUN-OFF OCCURS,
    NOTIFY(ING 10)
RTECS #:9999999ZZ

=====================  Hazards Identification  =====================

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES  Skin:NO  Ingestion:NO
Reports of Carcinogenicity:NTP:NO    IARC:NO	OSHA:NO
Health Hazards Acute and Chronic:ACUTE:EYE:MAY CAUSE SEVERE IRRIT,
    REDNESS, TEARING, BLURRED VISION. SKIN:PRLNGD/RPTD CNTCT MAY CAUSE
    MOD IRRIT, DEFAT, DERM. INHAL:EXCESS INHAL OF VAPS MAY CAUSE NASAL
    & RESP IRRIT, CNS EFTS INCLUDING  DIZZINESS, WEAKNESS, FATIGUE,
    NAUS, HEADACHE, & POSSIBLE UNCONSCIOUSNESS & EVEN ASPHYXIATION.
    INGEST:(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ:MAY CAUSE GI IRRIT, NAUS, VOMIT, &
    DIARR. ASPIR OF MATL INTO LUNGS MAY CAUSE CHEM PNEUMONIA WHICH MAY
    BE FATAL. CHRONIC:OVEREXP HAS APPARENTLY BEEN FOUND TO CAUSE THE
    FOLLOWING EFTS IN LAB AN IMALS:LIVER ABNORM, KIDNEY DMG,
    ANEMIA,LUNG DMG, EYE DMG, BRAIN DMG, SPLEEN DMG, NERV SYS DMG.
    OVEREXP HAS (ING 12)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.

=======================  First Aid Measures  =======================

First Aid:SKIN:THORO WASH W/SOAP & WATER. EYE:FLUSH WITH LARGE AMOUNTS
    OF WATER, LIFTING UPPER & LOWER LIDS OCCASIONALLY, GET MD.
    INGEST:DO NOT INDUCE VOMITING, KEEP PERSON WARM, QUIET & GET MD.
    ASPIRATION OF M ATERIAL INTO LUNGS DUE TO VOMIT CAN CAUSE CHEM
    PNEUMONIA WHICH MAY BE FATAL. INHAL:MOVE TO FRESH AIR. IF BRTHG IS
    DFCLT, GIVE O*2. IF BRTHG HAS STOPPED, GIVE ARTF RESP. KEEP PERS
    WARM, QUIET & GET MD.

=====================  Fire Fighting Measures  =====================

Flash Point Method:TCC
Flash Point:-4F,-20C
Lower Limits:1.2%
Extinguishing Media:REGULAR FOAM, CARBON DIOXIDE OR DRY CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
    PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:MATL IS HIGHLY VOLATILE & READILY GIVES
    OFF VAPS WHICH MAY TRAVEL ALONG GROUND OR BE MOVED BY VENT, &
    IGNITED BY PILOT LIGHTS, OTHER FLAMES, SPARKS, (SUPDAT)

==================  Accidental Release Measures  ==================

Spill Release Procedures:SMALL SPILL:ABSORB LIQ ON PAPER, VERMICULITE,
    FLOOR ABSORBENT OR OTHER ABSORBENT MATERIAL. LRG SPILL:ELIM ALL
    IGNIT SOURCES (FLARES, FLAMES INCL PILOT LIGHT, ELEC SPARKS). PERS
    NOT WEARING PROT EQUIP  SHOULD BE EXCLUDED FROM SPILL AREA UNTIL
    (ING 7)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

======================	Handling and Storage  ======================

Handling and Storage Precautions:CONTAINERS OF THIS MATERIAL MAY BE
    HAZARDOUS WHEN EMPTIED. SINCE EMPTIED CONTAINERS RETAIN PRODUCT
    RESIDUES (VAP, LIQ, &/OR SOLID).
Other Precautions:ALL HAZARD PRECAUTIONS GIVEN SHOULD BE OBSERVED.

=============  Exposure Controls/Personal Protection  =============

Respiratory Protection:ALL RESPS MUST BE NIOSH/MSHA APPROVED. IF
    WORKPLACE EXPOS LIMIT(S) OF PROD OR ANY COMPONENT IS EXCEEDED AN
    AIR SUPPLIED RESP IS ADVISED IN ABSENCE OF PROPER ENVIRON CNTRL.
    OSHA REGS ALSO PERMIT OTHER  RESPS (NEGATIVE PRESS TYPE) (ING 11)
Ventilation:PROVIDE SUFFICIENT MECHANICAL (GENERAL AND/OR LOCAL
    EXHAUST) VENTILATION TO MAINTAIN EXPOSURE BELOW TLV(S).
Protective Gloves:NEOPRENE GLOVES.
Eye Protection:CHEMICAL WORKERS GOGGLES .
Other Protective Equipment:NOT REQUIRED UNDER NORMAL CONDITIONS OF USE.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
EXPLO HAZ:HEATERS, SMKNG, ELEC MOTORS, STATIC DISCHARGE, OR OTHER IGNIT
    SOURCES AT LOCATIONS DISTANT FROM MATL HANDLING PT. NEVER USE
    WELDING/CUTTING TORCH NEAR DRUM (EVEN EMPTY) BECAUSE PROD (EVEN JU
    ST RESIDUE) CAN IGNITE EXPLO. ALL FIVE GALLON PAILS & LARGER METAL
    CNTNRS INCL TANK CARS/TRUCKS SHOULD BE (ING 6)

==================  Physical/Chemical Properties  ==================

Boiling Pt:B.P. Text:133F,56C
Vapor Pres:181.7 @68F
Vapor Density:HVR/AIR
Spec Gravity:0.840 @ 68F
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:CLEAR COLORLESS LIQUID
Percent Volatiles by Volume:100

=================  Stability and Reactivity Data  =================

Stability Indicator/Materials to Avoid:YES
AVOID CONTACT WITH STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:AVOID HEAT, OPEN FLAME, AND PROLONGED
    STORAGE AT ELEVATED TEMPERATURES.
Hazardous Decomposition Products:NONE SPECIFIED BY MANUFACTURER.

====================  Disposal Considerations  ====================

Waste Disposal Methods:SMALL AND LARGE SPILLS:DISPOSE OF IN ACCORDANCE
    WITH LOCAL, STATE AND FEDERAL REGULATIONS.

 Disclaimer (provided with this information by the compiling agencies):
 This information is formulated for use by elements of the Department
 of Defense.  The United States of America in no manner whatsoever,
 expressly or implied, warrants this information to be accurate and
 disclaims all liability for its use.  Any person utilizing this
 document should seek competent professional advice to verify and
 assume responsibility for the suitability of this information to their
 particular situation.